{"title":"Chemicals","description":"\u003cp\u003eThe complete brewery cleaning and sanitation program — alkaline CIP cleaners, acid cleaners for beerstone and passivation, self-foaming detergents for exterior surfaces, and sanitizers across peracetic, iodophor, and chlorine dioxide chemistries, plus glycol, process acids, and draft line care. Every product page prints the dose, the cost per working gallon, and the SDS and TDS. Ships LTL on your pallet with no hazmat fees.\u003c\/p\u003e","products":[{"product_id":"ace-complete","title":"Ace Complete","description":"\u003cp\u003eAce Complete is a one-step CIP recirculation cleaner — a heavy-duty alkaline cleaner that combines the caustic and acid cycles into a single pass. For breweries running daily CIP, that means no separate acid wash and no second rinse.\u003c\/p\u003e\n\u003cp\u003eA proprietary blend of detergents, surfactants, and water conditioning agents penetrates and removes tenacious soils while lifting mineral scale and preventing it from redepositing, leaving stainless bright. It controls hard water across the pH range, so performance doesn't fall off with your water supply. Low foaming, so it recirculates cleanly.\u003c\/p\u003e\n\u003cp\u003eFor cold-side equipment, use 1 to 4 oz per gallon of hot water. For hot-side equipment, use 1 to 6 oz per gallon. Dilution varies with soil type and load. A 1% solution runs above pH 12. Available in 5-gallon pails, 15-gallon carboys, and 55-gallon drums.\u003c\/p\u003e\n\u003cp\u003e\u003cstrong\u003eThe real comparison isn't per gallon — it's per cycle.\u003c\/strong\u003e At the cold-side dose, Ace Complete runs about $0.34 per working gallon. The two-step alternative — Kettle Wash Plus at about $0.27, plus Acid 36 at about $0.12 on the cycles where the acid wash runs — averages roughly $0.31–$0.33 per gallon with an acid rinse every second or third cycle. On chemical cost alone, it's a wash. What the two-step program really costs is the acid cycle itself: a second fill, a second heat-up, a second recirculation, and a second rinse — double the water, effluent, energy, and tank time every time it runs. At the hot-side dose Ace Complete runs about $0.48 per gallon, and the eliminated cycle still pays for the difference many times over. If your municipality monitors discharge pH — federal pretreatment rules prohibit sewer discharges below pH 5.0, and local limits are often tighter on both ends — every cleaning cycle you eliminate is pH-extreme effluent you don't have to neutralize, monitor, or answer for.\u003c\/p\u003e\n\u003cp\u003ePair it with a no-rinse peracetic sanitizer like Reflex and the full turnaround becomes one cleaning cycle and one sanitizing pass — no acid cycle, no final rinse. Switching to one-step doesn't banish acid from the brewery — it demotes it. Keep a pail of Acid 36 on the shelf for what acid is actually for: the periodic passivation cycle that protects your stainless, and touch-ups after repairs — and stop paying to run it as a routine wash.\u003c\/p\u003e\n\u003cp\u003eHighly alkaline — wear appropriate PPE and keep it off soft metals. The SDS and technical data sheet are linked below. DOT-regulated and ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gal Pail","offer_id":49202533007587,"sku":"4478","price":86.95,"currency_code":"USD","in_stock":false},{"title":"15 Gal Carboy","offer_id":49450923589859,"sku":"4526","price":233.95,"currency_code":"USD","in_stock":false},{"title":"55 Gal Drum","offer_id":49450923622627,"sku":"5426","price":784.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/complete_alkaline_recirculation_cleaner_container.png?v=1785260195"},{"product_id":"ace-defoamer","title":"Ace Defoamer","description":"\u003cp\u003eAce Defoamer is a 10% active, food-grade silicone antifoam for foam control anywhere in the brewery it becomes a problem — brewkettles, fermenters, yeast propagation, and blow-off buckets. It's FDA-authorized as a secondary direct food additive permitted in food for human consumption, and it's formulated specifically for filtered beers.\u003c\/p\u003e\n\u003cp\u003eIf you're converting from another chemical program, this is the direct replacement for Birko Antifoam 10, Birko All-Purpose Antifoam, and Five Star Defoamer 105 — same job, same chemistry class. A knocked-down kettle foam cap means bigger effective batch sizes, and controlled fermentation krausen means less blow-off loss.\u003c\/p\u003e\n\u003cp\u003eDosing is by the drop: add about one drop per five gallons during agitation, ideally before foaming starts rather than after. Subsequent additions are fine, but never exceed the FDA maximum of 200 ppm — roughly one drop per gallon. Available in 1-gallon jugs and a 4-gallon case of four jugs.\u003c\/p\u003e\n\u003cp\u003eWhite liquid emulsion, near-neutral pH, non-foaming by definition. It complies with 21 CFR 173.340 up to the 200 ppm limit. The SDS and technical data sheet are linked below. Non-hazardous: ships parcel or rides your pallet from Fort Worth or Atlanta — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202534449379,"sku":"4230","price":36.95,"currency_code":"USD","in_stock":true},{"title":"4 Gallon Case (4 × 1 Gallon)","offer_id":49453398819043,"sku":"414230","price":138.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/Defomer_1gal_0b410897-8027-497d-a12f-581b15057ebc.png?v=1785360705"},{"product_id":"reflex","title":"Reflex","description":"\u003cp\u003eReflex is a no-rinse acid sanitizer built for CIP and COP systems — a phosphate-free blend of peracetic and nitric acid that sanitizes and descales in a single pass. It is developed for food, dairy, and beverage processing and filtration equipment, and it does two jobs at once: it kills on contact and it keeps mineral scale from ever setting up.\u003c\/p\u003e\u003cp\u003eThat second job is what separates it from a straight peracetic sanitizer. Used regularly, Reflex prevents beerstone, milkstone, and limescale from forming on contact surfaces — the deposits that otherwise force a separate acid cycle. It has a high oxidation potential and works against a broad range of bacteria and fungi in cold or warm water. Use it on stainless steel and most plastics; it is safe to store in stainless tanks. Do not use it on copper, brass, aluminum, cast iron, or mild steel, and never use it with or around chlorinated products.\u003c\/p\u003e\u003cp\u003eSanitize previously cleaned surfaces at 1 to 3 fl oz per 6 gallons of water (95–286 ppm active peroxyacetic acid), after a potable water rinse. Hold at least one minute of contact, keep the sanitizing solution below 140°F, drain adequately, and do not rinse. In use the solution runs about pH 2.0–3.6; hold pH 2.5–4 when you are targeting beerstone or mineral scale removal. For RO, UF, and similar membrane systems, 1 fl oz per 4–6 gallons of feed water is the minimum effective dose. Available in 5-gallon pails and 52-gallon drums.\u003c\/p\u003e\u003cp\u003eReflex is a strong oxidizer. Store it upright in a cool, well-ventilated area shaded from sunlight and away from radiant heat, and keep it clear of caustics, reducing agents, and iron or yellow-metal contamination — contamination shortens shelf life and can induce decomposition. Expect roughly six months of shelf life when stored properly. The SDS and technical data sheet are linked below. This product is DOT-regulated and ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gal Pail","offer_id":49202535203043,"sku":"4528","price":159.95,"currency_code":"USD","in_stock":true},{"title":"52 Gal Drum","offer_id":49451035394275,"sku":"5427","price":1328.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/aeb-reflex.jpg?v=1780951670"},{"product_id":"ace-a-san","title":"Ace-A-San","description":"\u003cp\u003eAce-A-San is Ace Chemical's EPA-registered acid-anionic sanitizer — the same dodecylbenzene sulfonic acid chemistry class as Star San, in a wholesale-priced jug. It's a no-rinse final sanitizing step for pre-cleaned, hard non-porous surfaces: pipelines, tanks, filters, vats, and utensils.\u003c\/p\u003e\n\u003cp\u003eBeyond killing, it's passive on stainless and provides post-rinse acidification as it sanitizes, so the last thing touching your equipment is a mild acid film rather than alkaline residue. At recommended dilution it's remarkably economical — a single gallon makes roughly 640 gallons of working sanitizer.\u003c\/p\u003e\n\u003cp\u003eSanitize previously cleaned equipment at 1 fl oz per 5 gallons of water (200 ppm active). Dip, brush, or spray, allow at least 2 minutes of contact, drain well, and air dry — no potable rinse required at or below 400 ppm. Pre-clean first with an alkaline cleaner at 130–160°F and rinse before sanitizing. Prepare manual solutions fresh daily. Available in 1-gallon jugs and a 4-gallon case of four jugs.\u003c\/p\u003e\n\u003cp\u003eConcentrated acid at full strength: pH 2 at a 1% solution, moderate foaming, keep it off soft metals, and wear appropriate PPE when handling the concentrate. The SDS and technical data sheet are linked below. The 1-gallon jug ships parcel as a DOT Limited Quantity — one jug per shipment — while the 4-gallon case rides your pallet LTL, and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202536055011,"sku":"4198","price":36.95,"currency_code":"USD","in_stock":true},{"title":"4 Gallon Case (4 × 1 Gallon)","offer_id":49453408911587,"sku":"414198","price":138.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/ace-a-san---1-gallon-jug.jpg?v=1780951671"},{"product_id":"ace-o-dine-lf","title":"Ace-O-Dine LF","description":"\u003cp\u003eAce-O-Dine LF is Ace Chemical's EPA-registered, low-foaming iodophor sanitizer with a no-rinse claim — the iodine option for breweries that want the classic brown-bottle chemistry in a formulation built for CIP and spray systems rather than buckets. It sanitizes all food-contact surfaces after cleaning and doubles as an environmental bactericide for walls, floors, and conveyors.\u003c\/p\u003e\n\u003cp\u003eThe LF is the point: low foaming means it recirculates through spray balls and CIP loops without foaming out, which most consumer iodophors can't do. A potassium hydroxide–based formulation with a blend of chelants keeps it free-rinsing and effective in hard water across the pH range.\u003c\/p\u003e\n\u003cp\u003eSanitize at 1 fl oz per 5 gallons of cold or lukewarm water — that's 25 ppm titratable iodine, the level federally permitted with no potable rinse. Contact times: 1 minute for equipment, 5 minutes for tanks and vats, 2 minutes for environmental surfaces. It also pre-cleans at 1–2 fl oz per 5 gallons before the sanitizing pass. Never use hot water with an iodophor. Available in 1-gallon jugs and a 4-gallon case of four jugs.\u003c\/p\u003e\n\u003cp\u003eDark brown liquid with a characteristic iodine odor; a 1% solution runs below pH 6. Iodophors can stain plastics with prolonged contact, so drain and air dry rather than soaking. The SDS and technical data sheet are linked below. The 1-gallon jug ships parcel as a DOT Limited Quantity — one jug per shipment — while the 4-gallon case rides your pallet LTL from Fort Worth or Atlanta, and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202536710371,"sku":"4123","price":37.95,"currency_code":"USD","in_stock":true},{"title":"4 Gallon Case (4 × 1 Gallon)","offer_id":49453414383843,"sku":"414123","price":141.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/ace-o-dine-lf---1-gallon-jug.jpg?v=1780951671"},{"product_id":"acid-36","title":"Acid 36","description":"\u003cp\u003eAcid 36 is Ace Chemical's recirculation and passivating acid — a blend of phosphoric and nitric acid that cleans and protects in the same pass. It's the acid side of a complete CIP program, pairing with an alkaline cleaner like Kettle Wash to handle what caustic leaves behind.\u003c\/p\u003e\n\u003cp\u003eAs a cleaner it strips beerstone, hard water scale, and mineral deposits from stainless, leaving surfaces bright. As a passivating acid it restores and maintains the protective layer on quality stainless steel, so every cleaning cycle is also a maintenance cycle. Low-foaming and free-rinsing, it recirculates cleanly through spray balls and leaves no residue, and it holds up in hard water.\u003c\/p\u003e\n\u003cp\u003eFor routine cleaning, dose 1\/4 to 2 oz per gallon depending on soil load and rinse thoroughly. For passivating new or freshly welded stainless after alkaline cleaning, use 6 to 12 oz per gallon at no more than 140°F, recirculated at least 45 minutes; where recirculation isn't possible a stronger solution up to 25% may be needed. A 1% solution runs pH 2. Available in 5-gallon pails, 15-gallon carboys, and 55-gallon drums.\u003c\/p\u003e\n\u003cp\u003eConcentrated and corrosive: wear appropriate PPE and keep it off soft metals. The SDS and technical data sheet are linked below. DOT-regulated and ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gal Pail","offer_id":49202537922787,"sku":"4124","price":74.95,"currency_code":"USD","in_stock":false},{"title":"15 Gal Carboy","offer_id":49450467983587,"sku":"4213","price":212.95,"currency_code":"USD","in_stock":true},{"title":"55 Gal Drum","offer_id":49450468016355,"sku":"4887","price":699.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/Acid-36_5gal.png?v=1785962411"},{"product_id":"brew-clean","title":"Brew-Clean","description":"\u003cp\u003eBrew-Clean is Ace Chemical's non-caustic alkaline powder — a full-strength CIP and COP cleaner for breweries that want serious cleaning performance without caustic on the shelf. Formulated with sodium silicate, controlled-foam surfactants, buffering compounds, water conditioners, and a synergistic oxidizing agent.\u003c\/p\u003e\n\u003cp\u003eNon-caustic means it's safe on most soft metals and easier on your crew, which matters for hand-cleaning and COP work where contact is likely. The surfactant blend penetrates soils and deposits, it stays low-foaming through recirculation, and it rinses free in hard water without leaving residue.\u003c\/p\u003e\n\u003cp\u003eUse ½ to 3 oz per gallon of water and recirculate 20 to 40 minutes — clean vessels at 140°F and line circuits at 160°F, then rinse thoroughly with fresh water. A 1% solution runs pH 12. Available as a 40 lb box of four 10 lb jars, a 45 lb bucket, and a 400 lb drum.\u003c\/p\u003e\n\u003cp\u003eAs a powder it ships dense and stores indefinitely — no freeze risk, no wasted freight on water. One caution worth knowing: it contains sodium metasilicate, which can etch glass if it's allowed to dry on the surface without a thorough rinse. The SDS and technical data sheet are linked below. The 10 lb jar and 40 lb box can ship parcel or ride your pallet; the 45 lb bucket and 400 lb drum ship LTL only — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"10 lb Jar","offer_id":49450995548387,"sku":"4128","price":39.95,"currency_code":"USD","in_stock":false},{"title":"40 lb Box (4×10 lb)","offer_id":49202540052707,"sku":"414128","price":149.95,"currency_code":"USD","in_stock":false},{"title":"45 lb Bucket","offer_id":49450990764259,"sku":"4439","price":139.95,"currency_code":"USD","in_stock":false},{"title":"400 lb Drum","offer_id":49450990797027,"sku":"5983","price":969.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/brew-clean-40-lb-box.jpg?v=1780951675"},{"product_id":"clean-tap-1-gallon-jug","title":"Clean Tap","description":"\u003cp\u003eClean Tap is Ace Chemical's taproom draft line cleaner — a full-strength alkaline liquid built to pull beer soils, beerstone, and mineral deposits out of draft lines. The design brief is right in the name: it delivers the cleaning power of a full-strength line cleaner with a lower caustic content, which makes it the right choice where taproom staff, not cellar crew, are running the cleaning unit.\u003c\/p\u003e\n\u003cp\u003eIt's highly chelated, which is what does the work in hard water: the chelant package penetrates and lifts soils, eliminates beerstone, and keeps minerals from redepositing as the line rinses. It rinses exceptionally clean — the difference between a line that tastes like beer and a line that tastes like cleaner.\u003c\/p\u003e\n\u003cp\u003eTo clean a line: flush the beer out with hot tap water, then mix ½ to 2 oz of Clean Tap per quart of hot water in the cleaning unit — always adding the chemical to the water. Pump the solution into the line and let it work 3 to 5 minutes, then rinse the unit and flush the lines thoroughly with hot water. If hot water isn't available, prepare the solution at 2 to 6 oz per quart instead. A 1% solution runs pH 11–12, and at the label dose a single gallon jug covers dozens of cleaning sessions.\u003c\/p\u003e\n\u003cp\u003eClear, colorless, low-foaming liquid, kosher certified. It's a potassium hydroxide chemistry — corrosive at full strength, so wear appropriate PPE, keep it off soft metals, and never mix it with acids. The SDS and technical data sheet are linked below. DOT-regulated (UN1814, Class 8) and ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202541723875,"sku":"4833","price":13.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/clean_tap_1gal_689da07f-6524-469f-9ded-26e895a5dbe5.png?v=1785279789"},{"product_id":"ezi-action-pump","title":"Ezi-action Pump","description":"\u003cp\u003eThe Ezi-action Pump is the simplest way to get chemicals out of a pail, carboy, or drum without pouring, tipping, or siphoning. High-volume delivery at low pressure means less splashing and less spillage — which matters most with exactly the products it's built for: caustics, acids, and sanitizers that you do not want running down the side of a container or across your hands.\u003c\/p\u003e\n\u003cp\u003eIt's a dry-break, drum-mounted hand pump resistant to a wide range of brewery chemistries, and it drops straight into standard container openings. Because it draws from the bottom, you get the last of the product out instead of leaving inches of expensive chemical behind — the difference between a pail you finished and a pail you gave up on.\u003c\/p\u003e\n\u003cp\u003eMatch the pump to the container: the 5-gallon pump for pails, the 15\/30-gallon for carboys, and the 55-gallon for drums. If you buy chemicals in more than one size, you'll want more than one pump — they are not interchangeable across container heights.\u003c\/p\u003e\n\u003cp\u003eEquipment, not a chemical: no dose, no dilution, and nothing to rinse. Ships parcel or rides your pallet from Fort Worth or Atlanta — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gallon Pail Pump","offer_id":49202542837987,"sku":"5447","price":49.95,"currency_code":"USD","in_stock":true},{"title":"15\/30 Gallon Carboy Pump","offer_id":49453483262179,"sku":"5446","price":59.95,"currency_code":"USD","in_stock":true},{"title":"55 Gallon Drum Pump","offer_id":49453483294947,"sku":"5445","price":69.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/ezi_action_pump_5_gal.jpg?v=1780951678"},{"product_id":"foam-brite","title":"Foam Brite","description":"\u003cp\u003eFoam Brite is a concentrated, self-foaming acid detergent — the acid side of exterior cleaning. It removes beerstone, hard water scale, and other mineral deposits, and it brings dulled stainless steel back to its original shine. It is built to generate copious, stable foam in hand-held and air-injected foamers, and it doubles as a strong manual acid cleaner for bucket-and-brush work.\u003c\/p\u003e\u003cp\u003eThe concentrated surfactant blend is what does the work here: it penetrates mineral scale rather than just sitting on top of it, holds foam on vertical surfaces long enough to matter, performs in hard water, and rinses free without residue. Because it is concentrated, a pail goes a long way — which is the whole economic argument for it.\u003c\/p\u003e\u003cp\u003e\u003cstrong\u003eRead the per-gallon number the right way.\u003c\/strong\u003e At the foam dose, Foam Brite runs about $1.09 per working gallon — four times what a CIP caustic costs per gallon, and that's exactly the wrong comparison. A CIP cycle recirculates its entire loop volume, so pennies per gallon multiply by the tankful. A foam session uses only the few gallons that actually cling to the surface: five gallons of mixed solution — enough to coat a lot of tank exterior, wall, and floor — costs about $5.44. For surface work, the unit that matters is cost per foaming session, and by that unit a pail of concentrate stretches across months of them.\u003c\/p\u003e\u003cp\u003eFor foam cleaning, add 4 to 8 fl oz per gallon of hot water to the foam tank, apply, and allow 10 to 20 minutes of dwell on stainless — but never let the solution dry on the surface. Rinse well with fresh water. On ferrous metals, keep dwell to 5 to 10 minutes and follow with an alkaline cleaner to neutralize and prevent rust, then a final clear water rinse. For manual cleaning, use 2 to 4 fl oz per gallon of warm to hot water. Heavy soil and scale may need higher concentrations. A 1% solution sits around pH 2.\u003c\/p\u003e\u003cp\u003eAvoid soft metals — this is a concentrated acid. Store in a cool, dry area with the container closed, and keep it away from chlorinated products and alkaline chemistry. The SDS and technical data sheet are linked below. Ships LTL on your pallet from Fort Worth or Atlanta — we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gal Pail","offer_id":49202543755491,"sku":"4199","price":115.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/Foam_Brite_5gal.png?v=1785962411"},{"product_id":"foam-klor","title":"Foam Klor","description":"\u003cp\u003eFoam Klor is a self-foaming chlorinated alkaline detergent for exterior surfaces — the chlorinated counterpart to Foam Safe. It uses the oxidizing power of chlorine to keep stainless bright and free of protein bluing, and it is built to penetrate and lift the soils that collect on brewing equipment and environmental surfaces. Chlorinated foaming cleaners are the industry standard for stainless throughout the food industry.\u003c\/p\u003e\u003cp\u003eChlorine is what separates it from a plain alkaline foamer: it strips protein soils, pulls the blue haze off stainless, and controls odors along the way — real benefits for plant hygiene, not just appearance. The surfactant blend gives it maximum detergency and copious, stable foam suited to air-operated and hand-held foam units. It performs in hard water, rinses free without residue, and is phosphate-free and biodegradable.\u003c\/p\u003e\u003cp\u003e\u003cstrong\u003eRead the per-gallon number the right way.\u003c\/strong\u003e At the foam dose, Foam Klor runs about $0.72 per working gallon — well above what a CIP caustic costs per gallon, and that's exactly the wrong comparison. A CIP cycle recirculates its entire loop volume, so pennies per gallon multiply by the tankful. A foam session uses only the few gallons that actually cling to the surface: five gallons of mixed solution — enough to coat a lot of tank exterior, wall, and floor — costs about $3.61. For surface work, the unit that matters is cost per foaming session, and by that unit a pail of concentrate stretches across months of them.\u003c\/p\u003e\u003cp\u003eFor foam cleaning, use roughly 4 to 8 fl oz per gallon of hot water. For manual cleaning, use ½ to 4 fl oz per gallon of warm water. For high-pressure cleaning, use ½ to 2 fl oz per gallon. Rinse well with fresh water in every case. A 1% solution runs above pH 12.\u003c\/p\u003e\u003cp\u003eAvoid soft metals — this is chlorinated alkaline chemistry, so aluminum and other soft metals are out; use Foam Safe there instead. Never mix it with acid products, which releases chlorine gas. Store in a cool, dry area with the container closed. The SDS and technical data sheet are linked below. Ships LTL on your pallet from Fort Worth or Atlanta — we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gal Pail","offer_id":49202544640227,"sku":"4200","price":76.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/Foam_Klor_5gal.png?v=1785184278"},{"product_id":"foam-safe","title":"Foam Safe","description":"\u003cp\u003eFoam Safe is a concentrated, self-foaming alkaline detergent built for exterior surface cleaning in a brewery — tanks, walls, floors, kegs, and equipment exteriors. It is non-caustic, drawing its alkalinity from silicate instead, which is what makes it safe on soft metals including aluminum. That is the whole point of this product: real cleaning power that will not eat your aluminum.\u003c\/p\u003e\u003cp\u003eIt is solventized and carries a complex surfactant blend, so it is especially effective on greases and mineral oils, and it penetrates, dislodges, and suspends the soils that actually collect on brewery exteriors. It generates copious, stable foam that clings where you spray it, works in hard water, and rinses free without leaving residue behind.\u003c\/p\u003e\u003cp\u003e\u003cstrong\u003eRead the per-gallon number the right way.\u003c\/strong\u003e At the foam dose, Foam Safe runs about $0.66 per working gallon — more than double what a CIP caustic costs per gallon, and that's exactly the wrong comparison. A CIP cycle recirculates its entire loop volume, so pennies per gallon multiply by the tankful. A foam session uses only the few gallons that actually cling to the surface: five gallons of mixed solution — enough to coat a lot of tank exterior, wall, and floor — costs about $3.28. For surface work, the unit that matters is cost per foaming session, and by that unit a pail of concentrate stretches across months of them.\u003c\/p\u003e\u003cp\u003eFor foam cleaning, use 4 to 8 fl oz per gallon of hot water, adjusting for your foam equipment and soil load. For manual cleaning, use 2 to 4 fl oz per gallon of warm to hot water. Either way, rinse thoroughly with fresh water. A 1% solution sits around pH 10. Foam Safe contains sodium metasilicate — rinse it fully and do not let it dry on glass, where it can etch. Safe on most soft metals when used as directed, but test your use solution on an inconspicuous area or a scrap piece of similar metal first.\u003c\/p\u003e\u003cp\u003eStore in a cool, dry area and keep the container closed when not in use. The SDS and technical data sheet are linked below. Ships LTL on your pallet from Fort Worth or Atlanta — we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gal Pail","offer_id":49202545164515,"sku":"5673","price":69.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/Foam_Safe_5gal_b55f17ec-b101-4181-b481-aaeeba370ff8.png?v=1785253394"},{"product_id":"hydrofoamer-481","title":"Hydrofoamer 481","description":"\u003ch4\u003eThe HydroFoamer 481 is easy to use\u003c\/h4\u003e\n\u003cp\u003eIncrease labor productivity with the HydroFoamer.. These easy to use spraying and foaming devices can be taken anywhere your hose can reach. Chemical concentrates will perform at their peak because they are mixed only as they are applied. Just fill the concentrate container and connect the dispenser to a water source. Quick application, properly diluted chemicals, and minimal waste make the HydroFoamer devices some of the most popular products in the industry.\u003c\/p\u003e\n\u003cp\u003e\u003cspan\u003eFeatures \u0026amp; Benefits:\u003c\/span\u003e\u003c\/p\u003e\n\u003cul\u003e\n\u003cli\u003eProven, reliable components\u003c\/li\u003e\n\u003cli\u003eNon-electric\u003c\/li\u003e\n\u003cli\u003eNo installation required\u003c\/li\u003e\n\u003cli\u003eCompact, easy to store\u003c\/li\u003e\n\u003cli\u003eEnhanced safety due to reduced exposure to chemicals\u003c\/li\u003e\n\u003cli\u003eMaximum cleaning product performance\u003c\/li\u003e\n\u003c\/ul\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"Default Title","offer_id":49202545688803,"sku":"4201","price":89.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/hydrofoamer_481.jpg?v=1780951681"},{"product_id":"kettle-wash","title":"Kettle Wash","description":"\u003cp\u003eKettle Wash is Ace Chemical's high-alkaline recirculation cleaner — a sodium hydroxide liquid built for CIP and COP cycles throughout the brewhouse. It's the workhorse for brew kettles, mash tuns, hot liquor tanks, lauter tuns, and chillers, where cooked-on protein, trub, and hop resin need genuine caustic strength to break down.\u003c\/p\u003e\n\u003cp\u003eLow-foaming by design, so it recirculates cleanly through spray balls and pumps without foaming out mid-cycle. A blend of chelating agents controls water hardness across the alkalinity range, penetrating and lifting beerstone and mineral scale instead of letting it build cycle after cycle. It rinses free and leaves no residue behind.\u003c\/p\u003e\n\u003cp\u003eDose 1\/2 to 4 oz per gallon depending on soil load, circulate at 120–140°F, and rinse well with fresh water. A 1% solution runs pH 13. Available in 5-gallon pails, 15-gallon carboys, and 55-gallon drums — the drum sizes earn their keep in breweries running daily CIP.\u003c\/p\u003e\n\u003cp\u003eHighly alkaline and corrosive: wear appropriate PPE and keep it off soft metals. The SDS and technical data sheet are linked below. DOT-regulated and ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gallon Pail","offer_id":49447550124259,"sku":"4126","price":90.95,"currency_code":"USD","in_stock":false},{"title":"15 Gallon Carboy","offer_id":49447550157027,"sku":"4214","price":271.95,"currency_code":"USD","in_stock":false},{"title":"55 Gallon Drum","offer_id":49447550189795,"sku":"4888","price":931.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/Kettle_Wash_5gal_5f895485-9519-4d93-bf6e-ed554710cde0.png?v=1785251778"},{"product_id":"kettle-wash-plus-30-gallon-carboy","title":"Kettle Wash Plus - 30 Gallon Carboy","description":"\u003cp\u003eKettle Wash Plus in a 30-gallon carboy, the last of this size. Once it's gone, Kettle Wash Plus continues in the 5-gallon pail.\u003c\/p\u003e\u003cp\u003eKettle Wash Plus is a chlorinated, high-alkaline liquid CIP cleaner formulated with sodium hydroxide, water conditioning agents, and chlorine. It penetrates, loosens, and removes tenacious brewing soils, strips protein bluing from stainless, stays low-foaming for recirculation, and rinses free in hard water. Use 1 to 4 fl oz per gallon of hot water at 120 to 160°F and rinse thoroughly. Keep it off soft metals and never mix it with acids.\u003c\/p\u003e\u003cp\u003eThe SDS and technical data sheet are linked below. Ships LTL on your pallet only, never by parcel carrier, and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"Default Title","offer_id":49202548310243,"sku":"6299","price":349.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/0d1190be1fa44628a8a98cc1280a7809no_selection_4ceae616-1295-412b-81f4-b7627a165a09.jpg?v=1780951684"},{"product_id":"kettle-wash-plus","title":"Kettle Wash Plus","description":"\u003cp\u003eKettle Wash Plus is a chlorinated, high-alkaline liquid CIP cleaner — the version of Kettle Wash you reach for when alkaline detergency alone is not enough and you need an oxidizer working alongside it. It is formulated with sodium hydroxide, water conditioning agents, and chlorine, and it is built for every CIP and COP procedure in the brewery.\u003c\/p\u003e\u003cp\u003eThe chlorine is the point of difference. It removes protein soils and the protein “bluing” that hazes stainless steel surfaces — the film that a straight caustic wash leaves behind. It penetrates, loosens, and lifts tenacious brewing soils, stays low-foaming so it recirculates cleanly through spray balls and CIP loops, controls hard water, and rinses free without residue.\u003c\/p\u003e\u003cp\u003eFor mechanical cleaning, use 1 to 4 fl oz per gallon of hot water at 120–160°F, adjusting for soil type and load, then rinse thoroughly with fresh water. A 1% solution runs above pH 12. Avoid soft metals — this is a caustic, chlorinated chemistry, so aluminum and other soft metals are out. Reach for Foam Safe instead where soft metals are in play.\u003c\/p\u003e\u003cp\u003eStore in a cool, dry area with the container closed when not in use, and keep it well away from acids — mixing chlorinated alkaline with acid releases chlorine gas. The SDS and technical data sheet are linked below. Ships LTL on your pallet from Fort Worth or Atlanta — we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gal Pail","offer_id":49202548932835,"sku":"4215","price":69.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/kettle_wash_plus_5gal.png?v=1785962411"},{"product_id":"kettle-wash-powder","title":"Kettle Wash Powder","description":"\u003cp\u003eKettle Wash Powder is the dry form of Ace Chemical's high-alkaline recirculation cleaner — sodium hydroxide detergency in a full-strength powder for CIP and COP cycles throughout the brewhouse. It does the same job as liquid Kettle Wash: brew kettles, mash tuns, hot liquor tanks, and lauter tuns, where cooked-on protein, trub, and hop resin need genuine caustic strength to break down.\u003c\/p\u003e\n\u003cp\u003eLow-foaming by design, so it recirculates cleanly through spray balls and pumps without foaming out mid-cycle. Water conditioning agents control hardness at both high and low alkalinity ranges, penetrating and lifting tenacious brewing soils instead of letting them build cycle after cycle, and it rinses free without leaving residue. As a powder it ships dense and stores indefinitely — no freeze risk, and none of your freight dollars spent moving water.\u003c\/p\u003e\n\u003cp\u003eDose ½ to 4 oz by weight per gallon of water depending on soil load, circulate at 120–140°F, and rinse well with fresh water. A 1% solution runs pH 12. Available in a 45 lb pail.\u003c\/p\u003e\n\u003cp\u003eHighly alkaline and corrosive: wear appropriate PPE and keep it off soft metals. The SDS and technical data sheet are linked below. Ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"45 lb Pail","offer_id":49202549326051,"sku":"4125","price":139.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/kettle_wash_poweder-45.png?v=1785962411"},{"product_id":"klor-scrub","title":"Klor Scrub","description":"\u003cp\u003eKlor Scrub is Ace Chemical's chlorinated alkaline powder for manual cleaning — the bucket-and-brush counterpart to the CIP cleaners. It's the one you reach for on general cleaning chores: parts, fittings, kegs, work surfaces, floors, and anywhere hands and foam do the work instead of a spray ball.\u003c\/p\u003e\n\u003cp\u003eA highly-built detergent combining high-foaming surfactants, balanced alkaline builders, and water conditioners, it delivers maximum soil penetration, removal, and suspension in any water condition — with the oxidizing benefits of chlorine on top. The chlorine strips protein soils and bluing from stainless, controls odors, and helps keep mold and mildew down. Controlled alkalinity means it's safe on soft metals when used as directed, and it rinses free without residue.\u003c\/p\u003e\n\u003cp\u003eUse ½ to 2 oz by weight per gallon of warm to hot water, varying with soil type and load, and rinse thoroughly with fresh water. A 1% solution runs pH 11. Available in a 45 lb bucket.\u003c\/p\u003e\n\u003cp\u003eOne rule that always applies to chlorinated alkaline chemistry: never mix with acids — the combination releases chlorine gas. Its copious stable foam is a feature for hand cleaning but makes it unsuitable for CIP recirculation; use Kettle Wash or Kettle Wash Powder for that. The SDS and technical data sheet are linked below. Ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"45 lb Bucket","offer_id":49202550112483,"sku":"6197","price":199.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/Klor_Scrub.png?v=1785184277"},{"product_id":"lactic-acid","title":"Lactic Acid","description":"\u003cp\u003eFood-grade lactic acid for brewing water adjustment. The standard choice for lowering mash and sparge pH into the target range, and for acidifying sparge water on lighter-colored beers where the grain bill provides little acidity of its own.\u003c\/p\u003e\n\u003cp\u003eLactic acid is favored for water treatment because it's flavor-neutral at typical brewing additions and works predictably — unlike acidulated malt, it lets you dial pH precisely without touching your grain bill. It's also used for acid rinses and pH correction in cleaning programs.\u003c\/p\u003e\n\u003cp\u003eDosage depends entirely on your water chemistry, grain bill, and target pH — use a water calculator or your own measurements rather than a fixed rate. Always add acid to water, never the reverse. Available in 1-gallon jugs, 5-gallon pails, and 55-gallon drums.\u003c\/p\u003e\n\u003cp\u003eCorrosive — wear appropriate PPE and store away from bases. The safety data sheet is linked below. Ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202550440163,"sku":"2707","price":39.95,"currency_code":"USD","in_stock":true},{"title":"5 Gal Pail","offer_id":49451007967459,"sku":"52707","price":169.95,"currency_code":"USD","in_stock":false},{"title":"55 Gal Drum","offer_id":49451008000227,"sku":"552707","price":1299.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/lactic-acid-1-gallon.jpg?v=1780951687"},{"product_id":"oxine","title":"Oxine","description":"\u003cp\u003eOxine is a 2% stabilized chlorine dioxide solution — an EPA-registered disinfectant and no-rinse sanitizer that works from the brewhouse to the tap. It delivers the kill power of hypochlorite and peracetic chemistries without the corrosion, fumes, or odor that make those a headache to live with.\u003c\/p\u003e\n\u003cp\u003eIt's a broad-spectrum biocide: bacteria including spore formers, viruses, algae, and mold, and it kills most beer spoilage organisms at low ppm. It's fast-acting on pathogens and biofilms, non-foaming, and non-corrosive on metals when used as directed. Two things brewers especially value: it makes an excellent yeast wash — eliminating contaminants without jeopardizing your production culture — and it's environmentally non-persistent, breaking down without forming THMs or chlorinated organics.\u003c\/p\u003e\n\u003cp\u003eOne critical step: Oxine must be activated. The active component is free chlorine dioxide, which is released only when the use dilution is adjusted to pH 5–6 with phosphoric or citric acid. Unactivated, it will not sanitize. For a sanitizing rinse on stainless and other hard non-porous food-contact surfaces — tanks, transfer lines, processing equipment — use a 100 ppm activated solution. Always follow label directions. Available in 1-gallon jugs and a 4-gallon case of four jugs.\u003c\/p\u003e\n\u003cp\u003eColorless liquid, slight chlorine odor, non-foaming, metal-safe as directed. The SDS and technical data sheet are linked below. Ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202551062755,"sku":"6126","price":29.95,"currency_code":"USD","in_stock":true},{"title":"4 Gallon Case (4 × 1 Gallon)","offer_id":49453414973667,"sku":"416126","price":111.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/20.png?v=1785279698"},{"product_id":"oxy-boost-1-gallon-jug","title":"Oxy-Boost","description":"\u003cp\u003eOxy-Boost is an oxygenated booster for alkaline cleaning — active oxygen and water conditioning agents added to your caustic or non-caustic CIP solution to raise its cleaning performance on difficult soils. It's the chlorine-free way to add oxidizing power to a cleaning cycle: where a chlorinated caustic uses chlorine to strip protein and staining, Oxy-Boost brings hydrogen peroxide chemistry to the same fight and breaks down to oxygen and water.\u003c\/p\u003e\n\u003cp\u003eIt works by releasing oxygen into the hot alkaline solution, where it penetrates, dislodges, and helps remove the soils a straight alkaline wash struggles with. Because it conditions water as it works, it holds up in hard water alongside the cleaner it's boosting. It pairs naturally with Kettle Wash, Kettle Wash Powder, or Brew-Clean when a stubborn tank needs more than the base chemistry — without reaching for chlorine.\u003c\/p\u003e\n\u003cp\u003eDose it into the alkaline CIP solution to a total concentration of 0.1% to 1.0% by volume — at that rate, a single gallon treats roughly 100 to 1,000 gallons of working solution. Run the solution at 115°F or above, which is where oxygen release happens. One rule that is never optional: \u003cstrong\u003edo not run it in closed systems\u003c\/strong\u003e — the released oxygen builds pressure, so the circuit must be able to vent.\u003c\/p\u003e\n\u003cp\u003eClear, colorless, non-foaming liquid, kosher certified. This is a stabilized hydrogen peroxide concentrate — a strong oxidizer — so wear appropriate PPE, keep it in its original container away from heat, sunlight, combustibles, caustics, and chlorinated products, and keep it off soft metals. The SDS and technical data sheet are linked below. DOT-regulated (UN2014, Class 5.1 oxidizer) and ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202551161059,"sku":"4831","price":19.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/Oxy-boost_1gal.png?v=1785279626"},{"product_id":"pace-376","title":"Pace 376","description":"\u003cp\u003ePace 376 is a 100% active, vegetable oil–based antifoam — the silicone-free defoamer, formulated specifically for unfiltered beers. That distinction is the whole point: if you're packaging hazy, unfiltered product, a silicone emulsion isn't the right tool, and Pace 376 is. Use it in brewkettles, fermenters, yeast propagation, and blow-off buckets.\u003c\/p\u003e\n\u003cp\u003eIt's FDA-authorized as a secondary direct food additive permitted in food for human consumption, complying with 21 CFR 173.340 at the recommended 200–400 ppm use dilution. Converting from another program? This directly replaces Birko Patco 376, Antifoam 100, and All-Purpose Antifoam.\u003c\/p\u003e\n\u003cp\u003eIn the brewkettle, add about ½ fl oz (15 mL) per barrel before the wort reaches a full boil, with further additions during the boil as needed. For fermenter foam control, use ¼ to 1 fl oz (11–30 mL). Always add during agitation, and add it before foaming becomes a problem rather than after. Foaming behavior varies with beer style and yeast strain, so treat these as starting points. Available in 1-gallon jugs and a 4-gallon case of four jugs.\u003c\/p\u003e\n\u003cp\u003eAmber opaque liquid with a vegetable oil odor, near-neutral pH, non-foaming by definition. The SDS and technical data sheet are linked below. Non-hazardous: ships parcel or rides your pallet from Fort Worth or Atlanta — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202551750883,"sku":"4239","price":44.95,"currency_code":"USD","in_stock":true},{"title":"4 Gallon Case (4 × 1 Gallon)","offer_id":49453421560035,"sku":"414239","price":168.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/22.png?v=1785360083"},{"product_id":"phosphoric-acid","title":"Phosphoric Acid","description":"\u003cp\u003eFood-grade phosphoric acid, 75% concentration, for brewing water adjustment and acid rinses. A workhorse acid in the brewery — used to lower mash and sparge pH, for final acid rinses after alkaline CIP, and as the acid step in a two-stage cleaning program.\u003c\/p\u003e\n\u003cp\u003ePhosphoric is the flavor-neutral choice at brewing concentrations, and at higher strength it doubles as a descaler that lifts beerstone and water scale from stainless. Many breweries keep it on hand for both jobs.\u003c\/p\u003e\n\u003cp\u003eDosage depends on your water chemistry, grain bill, and target pH — measure rather than follow a fixed rate. Always add acid to water, never the reverse. Available in 1-gallon jugs, 5-gallon pails, and 55-gallon drums.\u003c\/p\u003e\n\u003cp\u003eCorrosive: causes severe skin burns and eye damage. Wear appropriate PPE, store away from bases, and never mix with bleach or chlorinated products. The safety data sheet is linked below. The 1-gallon jug can ship parcel or ride your pallet; the 5-gallon pail and 55-gallon drum are DOT-regulated and ship LTL only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202552373475,"sku":"4834","price":39.95,"currency_code":"USD","in_stock":false},{"title":"5 Gal Pail","offer_id":49451009179875,"sku":"4843","price":169.95,"currency_code":"USD","in_stock":false},{"title":"55 Gal Drum","offer_id":49451009212643,"sku":"554834","price":1299.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/phosphoric_acid_-_5_gallon_pail_d8fb43b0-4cb4-4523-b134-0ab8517bbd0e.jpg?v=1780951696"},{"product_id":"propylene-glycol","title":"Propylene Glycol","description":"\u003cp\u003eFood-grade propylene glycol for brewery glycol chillers, jacketed tanks, and cold liquor loops. The industry-standard heat transfer fluid where a leak could contact product — unlike ethylene glycol, propylene glycol is non-toxic, which is why it's the only sensible choice around beer.\u003c\/p\u003e\n\u003cp\u003eRuns in fermenter jackets, brite tank jackets, chiller loops, and cold plates. Mixed with water to a concentration matched to your lowest working temperature, it protects against freeze-up while carrying heat away from fermentation.\u003c\/p\u003e\n\u003cp\u003eDilution depends on the freeze protection you need — higher glycol concentration lowers the freeze point but raises viscosity and reduces heat transfer efficiency, so match it to your actual lowest setpoint rather than over-concentrating. Use distilled or treated water for mixing to avoid scale in the loop. Available in 1-gallon jugs, 5-gallon pails, and 55-gallon drums.\u003c\/p\u003e\n\u003cp\u003eNon-hazardous and non-toxic, but the safety data sheet is being sourced from the manufacturer and will be posted here when it arrives. The 1-gallon jug and 5-gallon pail can ship parcel or ride your pallet; the 55-gallon drum ships LTL — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"1 Gallon Jug","offer_id":49202553782499,"sku":"4156","price":39.95,"currency_code":"USD","in_stock":true},{"title":"5 Gal Pail","offer_id":49451009868003,"sku":"154156","price":169.95,"currency_code":"USD","in_stock":true},{"title":"55 Gal Drum","offer_id":49451009900771,"sku":"1554156","price":1299.95,"currency_code":"USD","in_stock":false}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/propylene-glycol---1-gallon-jug_1_2840e73e-9f1e-4640-b9c9-717982234f7a.jpg?v=1780951697"},{"product_id":"san-o2-gard","title":"San-O2-Gard","description":"\u003cp\u003eSan-O2-Gard is Ace Chemical's EPA-registered peracetic acid sanitizer — an equilibrium mixture of peracetic acid, hydrogen peroxide, and acetic acid. It's the no-rinse final step after cleaning, used across CIP pipelines, fillers, tanks, chillers, and environmental surfaces.\u003c\/p\u003e\n\u003cp\u003ePAA kills fast and kills broadly — bacteria, yeasts, and fungi — and it does it at temperatures as low as 40°F, which matters in cold-side sanitation where hot water isn't an option. It works across a broad pH range, controls slime and biofilm, and is less corrosive to stainless than chlorinated sanitizers. It also cleans RO and UF membranes.\u003c\/p\u003e\n\u003cp\u003eSanitize food-contact surfaces at 1 to 6.1 oz per 6 gallons of water (roughly 200–400 ppm active), after cleaning and a potable rinse. Leave at least 60 seconds of contact, drain the excess, and do not rinse. A 1% solution runs below pH 3. Available in 5-gallon pails and 53-gallon drums.\u003c\/p\u003e\n\u003cp\u003eIt breaks down to water, acetic acid, and oxygen — environmentally about as clean as sanitation gets. Store the container upright in a ventilated area out of sunlight and away from heat, and keep it free of heavy metal and alkali contamination. The SDS and technical data sheet are linked below. DOT-regulated and ships LTL on your pallet only, never by parcel carrier — and we charge no hazmat fees, ever.\u003c\/p\u003e","brand":"TBI Pro Brew Supply","offers":[{"title":"5 Gal Pail","offer_id":49202555912419,"sku":"4122","price":156.95,"currency_code":"USD","in_stock":false},{"title":"53 Gal Drum","offer_id":49451012325603,"sku":"4795","price":1488.95,"currency_code":"USD","in_stock":true}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/files\/san-02-gard_5gal.png?v=1785279843"}],"thumbnail_url":"\/\/cdn.shopify.com\/s\/files\/1\/0708\/1174\/6531\/collections\/BL-15-ace-1_cd7eb700-2b99-4b7e-af84-90d85be429b2.png?v=1785173852","url":"https:\/\/www.probrewsupply.com\/collections\/chemicals.oembed?page=2","provider":"TBI Pro Brew Supply","version":"1.0","type":"link"}